2007 CHEVROLET EXPRESS 3500 — Problems, Recalls & Safety Data
N/A
Safety Rating
12
Owner Complaints
1
Recall
0
Service Bulletins
0
Investigations
Overview of the 2007 CHEVROLET EXPRESS 3500
The 2007 CHEVROLET EXPRESS 3500 has received a total of 12 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There has been 1 recall campaign affecting this vehicle, covering issues with EQUIPMENT ADAPTIVE/MOBILITY. The most commonly reported problems involve the Fuel System Gasoline (3 complaints), Air Bagsfrontal (1 complaint), and Child Seattether Strapwebbing (1 complaint).
Recalls for the 2007 CHEVROLET EXPRESS 3500
NHTSA has recorded 1 recall for the 2007 CHEVROLET EXPRESS 3500, potentially affecting up to 34 vehicles.
Recall 14V706000 — EQUIPMENT ADAPTIVE/MOBILITY
| 34 vehicles affected
Defect: Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006....
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015....
View full details →Owner Complaints for the 2007 CHEVROLET EXPRESS 3500
12 complaints have been filed with NHTSA for the 2007 CHEVROLET EXPRESS 3500. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Fuel System Gasoline | 3 | 0 | 0 | 0 | 0 |
| Air Bagsfrontal | 1 | 1 | 0 | 2 | 0 |
| Child Seattether Strapwebbing | 1 | 0 | 0 | 0 | 0 |
| Electrical System | 1 | 0 | 1 | 0 | 0 |
| Electronic Stability Control Esc | 1 | 0 | 0 | 0 | 0 |
| Equipment | 1 | 0 | 0 | 0 | 0 |
| Fuelpropulsion System | 1 | 0 | 0 | 0 | 0 |
| Power Trainautomatic Transmission | 1 | 0 | 0 | 0 | 0 |
| Seat Beltsfront | 1 | 0 | 0 | 0 | 0 |
| Structure | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
I WAS DRIVING DOWN THE ROAD ON THE HIGHWAY AND THE DRIVERS WINDOW BUTTONS CAUGHT FIRE
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 3500. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE MISFIRED AND STALLED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND IT WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS SEVERELY RUSTED DUE TO A FUEL TANK LEAK, AND BOTH NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT A VERY STRONG ODOR OF FUEL WAS PRESENT, WHICH WAS NOTICED APPROXIMATELY A YEAR AND A HALF AGO. THE VEHICLE WAS NOT REPAIRED. THE DEALER (RAYMOND CHEVROLET IN ANTIOCH, ILLINOIS) WAS CONTACTED AND THE VEHICLE WAS TAKEN IN FOR DIAGNOSTIC TESTING A YEAR AND A HALF AGO; HOWEVER, NO REPAIRS WERE MADE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
I OWN 4 CHEVROLET EXPRESS 3500'S AND TWO OF THE FOUR HAVE LEAKING GAS TANKS. *TR
GAS TANK LEAKING. I OWN FOUR 2007 CHEVY EXPRESS 3500 AND TWO OF THE VEHICLES HAVE LEAKING GAS TANKS. *TR
I GOT AN HUGE BANG AND JERK WHEN STARTING OFF FROM A STAND STILL. THE 2007 CHEVROLET EXPRESS 3500 WITH 6 LITRE ENGINE, ONLY HAD JUST 30,112 KM ON IT WHEN THIS FIRST STARTED TO HAPPEN. IT HAS NOT BEEN HEAVILY USED. NO TOWING OR HEAVY LOADS. IT CURRENTLY HAS 34088 KM ON THE TRUCK AND NOW DOES THE BANG AND JERK ALMOST EVERY TIME YOU START FROM A STAND STILL. RIGHT AFTER THAT FIRST TIME A RED CHECK ENGINE LIGHT ON DASHBOARD CAME ON. I BOUGHT AN INNOVA 3030 TO CHECK THE ERROR CODE. THE ERROR CODE WAS P0894 - I DID A SEARCH ON A SITE AND FOUND A NHTSA: ACTION NUMBER: 10021019 SERVICE BULLETIN NUMBER: 222381 FOR THIS CONDITION - SLIP CONDITION IN 2ND, 3RD, OR 4TH. *TR
Safety Rating for the 2007 CHEVROLET EXPRESS 3500
NHTSA has not yet tested the 2007 CHEVROLET EXPRESS 3500 in its New Car Assessment Program.
Technical Service Bulletins for the 2007 CHEVROLET EXPRESS 3500
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2007 CHEVROLET EXPRESS 3500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET EXPRESS 3500
- 2002 CHEVROLET EXPRESS 3500 — 3 complaints
- 2003 CHEVROLET EXPRESS 3500 — 14 complaints
- 2004 CHEVROLET EXPRESS 3500 — 18 complaints
- 2005 CHEVROLET EXPRESS 3500 — 26 complaints
- 2006 CHEVROLET EXPRESS 3500 — 17 complaints
- 2007 CHEVROLET EXPRESS 3500 (current)
- 2008 CHEVROLET EXPRESS 3500 — 12 complaints
- 2009 CHEVROLET EXPRESS 3500 — 11 complaints
- 2010 CHEVROLET EXPRESS 3500 — 5 complaints
- 2012 CHEVROLET EXPRESS 3500 — 5 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints