2004 CHEVROLET C5500 — Problems, Recalls & Safety Data
N/A
Safety Rating
1
Owner Complaint
0
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2004 CHEVROLET C5500
The 2004 CHEVROLET C5500 has received a total of 1 safety complaint filed with the National Highway Traffic Safety Administration (NHTSA). 2 technical service bulletins have been issued by General Motors, LLC for this model year. The most commonly reported problem area is the Fuel System Gasoline (1 complaint).
Recalls for the 2004 CHEVROLET C5500
There are no recalls on file with NHTSA for the 2004 CHEVROLET C5500. No Active Recalls
Owner Complaints for the 2004 CHEVROLET C5500
1 complaint has been filed with NHTSA for the 2004 CHEVROLET C5500. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Fuel System Gasoline | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
TL* THE CONTACT OWNS A 2004 CHEVROLET C5500. THE CONTACT STATED T WHILE DRIVING APPROXIMATELY 55 MPH UP HILL, THE VEHICLE BEGAN TO VIOLENTLY JERK BACK AND FORTH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT SOME OF THE FUEL INJECTORS FAILED. THE VEHICLE WAS REPAIRED; HOWEVER, APPROXIMATELY ONE DAY LATER, ONE OF THE INJECTORS FAILED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 69,000.
Safety Rating for the 2004 CHEVROLET C5500
NHTSA has not yet tested the 2004 CHEVROLET C5500 in its New Car Assessment Program.
Technical Service Bulletins for the 2004 CHEVROLET C5500
General Motors, LLC has issued 2 technical service bulletins (TSBs) for the 2004 CHEVROLET C5500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
PIT4013B — EQUIPMENT
This PI clarifies a service procedure for dealership technicians who may be unfamiliar with medium duty vehicle service procedures.
SB05-08-133-001B — SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH
ISUZU/GMC/CHEVROLET: DIAGNOSTIC INFORMATION FOR INOPERATIVE AIR SEATS, AIR HORN AND/OR EXHAUST BRAKE AND RELEASE OF NEW AUXILIARY AIR COMPRESSOR RELAY AND PRESSURE SWITCH ON RPO K16 VEHICLES. *PE
NHTSA Investigations for the 2004 CHEVROLET C5500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET C5500
- 2003 CHEVROLET C5500 — 3 complaints
- 2004 CHEVROLET C5500 (current)
- 2005 CHEVROLET C5500 — 10 complaints
- 2006 CHEVROLET C5500 — 11 complaints
- 2007 CHEVROLET C5500 — 3 complaints
- 2008 CHEVROLET C5500 — 1 complaint
- 2009 CHEVROLET C5500 — 0 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints