NHTSA Complaint #11446234 — 2016 VOLVO XC60

"The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling the oil each 4-6 weeks. The vehicle was taken to the dealer, Bobby Rahal of the South Hills, who diagnosed that the piston rings needed to be replaced for more than $4,000 or the dealer stated that adding oil to the car every month would be a cheaper and not unsafe solution. On January 1 while driving on the highway, far from home, in the rain and fog with 3 children in the car, the engine started riding rough. The vehicle was driven cautiously home and taken to the independent mechanic specializing in Volvos who diagnosed that the engine had failed and needed to be replaced. The independent mechanic said he has seen 4-5 Volvos this year with the same problem, and that there is something wrong with the 2015 2/5 engine for this car, but prior to that year, it has been a good engine, and since that year, it has been a good engine. The vehicle was towed to the dealer where it was purchased, Bobby Rahal Volvo of the North Hills, and the diagnosis was the same for the 6 year old car needing a new engine for more than $16,000. Since the car was purchased in November 2020 for $18K+, the customer is wondering if the dealer that sold the car and the dealer that was asked about the oil issue knew the car engine was likely defective, did not tell the contact and put the contact's family in an unsafe situation. The manufacturer was notified of the failure, and the contact is awaiting a response. The vehicle has not yet been repaired. The failure mileage was approximately 76,000, after less than 8,000 of vehicle ownership."