NHTSA Complaint #11432802 — 2013 TOYOTA RAV4

Note: This is a fully electric vehicle. It was made by Toyota, but the drive train (electric motor, battery, etc.) is made by Tesla. Earlier this summer (Around June 2021) while starting the vehicle from a stop, the vehicle either shifted to neutral (halfway through an intersection) or stalled. The vehicle displays a message saying "Check EV System". We have since taken it to two Toyota dealerships. The first (Toyota of Tacoma in Tacoma WA) said the 12V battery needed to be replaced, but the issue happened again almost immediately after we took the vehicle off the lot and completely stalled in the middle of a busy intersection. We brought it back to the same dealership who then said nothing was wrong with the vehicle. We also took the vehicle to a local auto repair shop that specializes in electric vehicles where they were able to recreate the issue but unfortunately were unable to work on the car as Tesla had locked the codes needed to diagnose the issues. The second dealership (Titus Will Toyota in Tacoma WA) was able to reproduce the issue, but they didn't have the equipment to work on the vehicle. They said that they spoke to the Toyota engineering team who told them that the speed sensor had moisture on it, and the coolant on the right side was low which indicates that coolant was leaking into the electric motor and the vehicle needed a new drive train. Toyota said that since the drive train was made by Tesla, they are unable to work on the vehicle and we would need to figure out how to get the vehicle from Washington to California to find a shop that could service the vehicle and completely replace the entire drive train - a diagnosis made and given over the phone. We purchased the vehicle just over a year ago in Washington and now it has a dangerous safety issue that neither Toyota nor Tesla is wanting anything to do with and that local repair shops cannot address.