NHTSA Complaint #10825375 — 2009 DODGE CHALLENGER

KNOWN TREMEC TR6060 ISSUE & DODGE REFUSES TO HELP!! STAR CASE# S1021000004 & K38556860. THE GREASE USED IN THE TRANSMISSION TURNS INTO A GLUE AT HIGH TEMPS CAUSING THE TRANS TO NOT SHIFT PROPERLY THROUGH THE GEARS EITHER GOING INTO GEAR OR GETTING STUCK COMING OUT OF GEAR. IF HOT ENOUGH THIS GREASE FUSES THE PILOT & THROWOUT BEARING TO THE INPUT SHAFT REQUIRING THOSE BE REPLACED AT MINIMUM. THIS HAPPENED TO ME & THE CAR COULD NOT BE PUT IN 1ST-4TH WITHOUT A SEVERE GRINDING NOISE. IT CAN BE HEARD IN THE TRANS & FELT IN BOTH THE STICK & CLUTCH PEDAL. THE ONLY WAY TO SLOW DOWN WAS TO PUT THE CAR IN NEUTRAL & USE THE BRAKES WITHOUT ANY ENGINE CONTROL. BECAUSE OF THIS HIGH HEAT FUSION I HAD TO HAVE ESSENTIALLY THE ENTIRE TRANS REBUILT (BEARINGS, SYNCHROS, INPUT SHAFT & GASKETS). WHEN I SPOKE WITH DODGE (BOTH THE NUMBER LISTED ON THEIR WEBSITE & LOCAL DEALERSHIP) THEY ACKNOWLEDGED THIS WAS A KNOWN PROBLEM & THAT THE PARTS HAVE BEEN "REWORKED" SO THE ISSUE DOESN'T CONTINUE. SAID PARTS ARE AT A COST OF $2,000 BEFORE LABOR. I WAS TOLD THAT BECAUSE MY CAR IS OUT OF WARRANTY BY DATE THAT I WAS NOT COVERED BECAUSE EVEN THOUGH THE ISSUE IS KNOWN & THERE ARE MULTIPLE REPORTS OF IT ALL OVER THE WEB THERE IS NO OFFICIAL RECALL & I HAVE TO PAY COMPLETELY OUT OF POCKET. THIS CAR IS ON 09 & HAS LESS THAN 30K MILES ON IT!! I'M STILL IN DISPUTES WITH DODGE AS OF NOW BUT THIS IS COMPLETELY UNACCEPTABLE.